MENDOCINO COUNTY AIR QUALITY MANAGEMENT DISTRICT

RULE 490 - FEDERAL NEW SOURCE PERFORMANCE STANDARDS (NSPS)

  1. The provisions of Part 60, Chapter 1, Title 40 of the Code of Federal Regulations (40 CFR Part 60), Standards of Performance for New Stationary Sources, which are in effect as of July 1, 1992, are incorporated herein as a part of the Rules and Regulations of the Mendocino County Air Quality Management District. All new sources of air contaminants or modifications to existing sources shall comply with the rules, standards, criteria and requirements set forth in those provisions. For the purpose of this rule, the word "Administrator" as used in the federal new source performance standards shall mean the Control Officer of the District, except that the Control Officer shall not be empowered to approve alternate or equivalent test methods nor alternative standards or work practices. Other deviations from these federal standards as presented in the Code of Federal Regulations and which were ordered by the District Board to suit the needs of the District are noted in the reference to the affected Subpart. [amended April 6, 1993]
  2. Whenever any source is subject to more than one rule, regulation, provision, or requirement relating to the control of any air contaminant, in cases of conflict or duplication, the most stringent rule, regulation provision, or requirement shall apply.
  3. Source types subject to New Source Performance Standards and corresponding citations in the Code of Federal Regulations are listed below: [amended April 6, 1993]

 

CATEGORY - NSPS 40 CFR 60 
Subpart
General Provisions 
Adoption and Submittal of State Plans for Designated Facilities 
Fossil - Fuel Fired Steam Generators 
Electric Utility Steam Generating Units 
Industrial-Commercial-Institutional Steam Generating Units 
Incinerators 
Portland Cement Plants 
Nitric Acid Plants 
Sulfuric Acid Plants 
Asphalt Concrete Plants 
Petroleum Refineries - Fluid Catalytic Cracking Unit Generators 
Petroleum Storage Vessels (constructed June 11, 1973 to May 19, 1978) 
Petroleum Storage Vessels (constructed after May 19, 1978) 
Volatile Organic Liquid Storage Vessels 
Secondary Lead Smelters 
Secondary Brass and Bronze Ingot Production  
Iron and Steel Plants  
Secondary Emissions from Basic Oxygen Process Steelmaking Facilities 
Sewage Treatment Plants  
Primary Copper Smelters  
Primary Zinc Smelters  
Primary Lead Smelters  
Primary Aluminum Reduction Plants  
Wet Process Phosphoric Acid Plants  
Super Phosphoric Acid Plants  
Diammonium Phosphate Plants  
Triple Super Phosphate Plants  
Granular Triple Super Phosphate Storage  
Coal Preparation Plants  
Ferro Alloy Production  
Steel Plants - Electric Arc Furnaces  
Electric Arc Furnaces and Argon-Oxygen Vessels  
Kraft Pulp Mills  
Glass Manufacturing (except Sec. 60292(d & e) 
Grain Elevators  
Surface Coating of Metal Furniture  
Stationary Gas Turbine  
Lime Manufacturing  
Lead - Acid Battery Manufacture  
Metallic Mineral Processing Plants  
Auto and Light - Duty Truck Surface Coating  
Phosphate Rock Plants  
Ammonium Sulfate Manufacturing  
Graphic Arts Industry - Rotogravure Printing  
Pressure Sensitive Tape & Label Surface Coating  
Industrial Surface Coating, Large Appliances  
Metal Coil Surface Coating 
Asphalt Processing and Asphalt Roofing Manufacture  
Synthetic Organic Chemical Manufacturing Industry  
Beverage Can Surface Coating Industry 
Bulk Gasoline Terminals  
New Residential Wood Heaters  
Rubber Tire Manufacturing Industry  
VOC Emissions from the Polymer Manufacturing Industry  
Flexible Vinyl and Urethane Coating & Printing  
Equipment Leaks of VOC in Petroleum Refineries  
Synthetic Fiber Production Facilities  
VOC Emissions from the Synthetic Organic Chemical Manufacturing Industry (SOCMI) Air Oxidation Unit Processes 
Petroleum Dry Cleaners  
Equipment Leaks of VOC from Onshore Natural Gas Processing Plants 
Onshore Natural Gas Processing Plants; SO2  
VOC Emissions from the Synthetic Organic Chemical Manufacturing Industry (SOCMI) Distillation Operations  
Non-metallic Mineral Processing Plants  
Wool Fiberglass Insulation Manufacturing Plants  
VOC Emissions from Petroleum Wastewater Systems  
Magnetic Tape Coating Facilities  
Industrial Surface Coating of Plastic Parts for Business Machines  
Polymeric Coating of Supporting Substrates Facilities 
Municipal Waste Combustors (56FR5488)  
Emission Guidelines and Compliance Times (56FR5514)  
Emission Guidelines & Compliance Times for Municipal Waste Combustors (56FR5514)  
Emission Guidelines and Compliance Times for Sulfuric Acid Production Units 
Calciners and Dryers in Mineral Industries 

A 
B 
D 
Da(1) 
Dc 
E 
F 
G 
H 
I 
J 
K 
Ka 
Kb(2) 
L 
M 
N 
Na 
O 
P 
Q 
R 
S 
T 
U 
V 
W 
X 
Y 
Z 
AA 
AAa 
BB 
CC 
DD 
EE(1) 
GG 
HH 
KK 
LL 
MM(1) 
NN 
PP 
QQ(1) 
RR(1) 
SS(1) 
TT(1) 
UU 
VV(2) 
WW(1) 
XX(3) 
AAA 
BBB 
DDD 
FFF(1) 
GGG(2) 
HHH(1) 
III 

JJJ(2) 
KKK 
LLL 

NNN 
OOO 
PPP 
QQQ 
SSS 
TTT 
VVV 
Ea 
C 
Ca 
Cb 
UUU

 

[amended April 6, 1993]

Notes:

  1. The emissions averaging periods specified in the federal standard are deleted and replaced with 24-hour maximum emissions averaging periods for affected facilities in the District.
  2. The observation of a leak in excess of the requirements of the rule constitutes a violation of the rule.
  3. California Air Resources Board (CARB) Certification and Test Procedures for Vapor Recovery Systems of Gasoline Delivery Tanks shall be followed in lieu of the federal procedure as shown in the CFR. Documentation and record keeping requirements shall record results of CARB Certification Tests.